volume | PIER Journals

Abstract

When demagnetization occurs, direct-drive permanent magnet synchronous wind generator exhibits problems of poor dynamic performance, weak immunity to disturbances and speed fluctuations. Aiming at these problems, this paper proposes a cascaded linear active disturbance rejection control method. First, the mathematical models of the generator during normal operation and demagnetization are described. Second, the linear active disturbance rejection controller (LADRC) for the speed and current loops is designed. The compensation for demagnetization disturbances at the speed loop's input is enabled by the control approach. The current output of the speed loop is imported as a rated value into the LADRC of the current loop. At the same time, the current is compensated at the input. Compensated speed and current accurately track the given values, and the goal of achieving demagnetization fault tolerance is met. Finally, this method is compared with dual-loop Proportional Integral (PI) control. The experimental results affirm that, under this control method, when demagnetization occurs, the speed fluctuation is reduced by 95.7%, the current response time decreased from 0.01 seconds to 0.001 seconds, and the electromagnetic torque ripple amplitude reduced by 50%. These experimental results fully validate the heightened fault tolerance and resistance to interference exhibited by the method advocated in this paper.

1. Prince, M. K. K., M. T. Arif, A. Gargoom, A. M. T. Oo, and M. E. Haque, "Modeling, parameter measurement, and control of PMSG-based grid-connected wind energy conversion system," Journal of Modern Power Systems and Clean Energy, Vol. 9, No. 5, 1054-1065, Sep. 2021. Google Scholar

2. Osman, A. M. and F. Alsokhiry, "Sliding mode control for grid integration of wind power system based on direct drive PMSG," IEEE Access, Vol. 10, 26567-26579, 2022. Google Scholar

3. He, S. and M. Wang, "Grey prediction pi control of direct drive permanent magnet synchronous wind turbine," 2020 IEEE 4th Conference on Energy Internet and Energy System Integration (EI2), 2032-2035, 2020.

4. Ullah, Z. and J. Hur, "A comprehensive review of winding short circuit fault and irreversible demagnetization fault detection in PM type machines," Energies, Vol. 11, 3309, 2018. Google Scholar

5. Zhang, Meiwei, Weili Li, and Haoyue Tang, "Demagnetization fault diagnosis of the permanent magnet motor for electric vehicles based on temperature characteristic quantity," IEEE Transactions on Transportation Electrification, Vol. 9, No. 1, 759-770, Mar. 2023. Google Scholar

6. Barmpatza, A. C. and J. C. Kappatou, "Study of a combined demagnetization and eccentricity fault in an AFPM synchronous generator," Energies, Vol. 13, 5609, 2020. Google Scholar

7. Zhou, P., D. Lin, Y. Xiao, N. Lambert, and M. A. Rahman, "Temperature-dependent demagnetization model of permanent magnets for finite element analysis," IEEE Transactions on Magnetics, Vol. 48, No. 2, 1031-1034, Feb. 2012. Google Scholar

8. Ancuti, M.-C., S. Musuroi, C. Sorandaru, M. Dordescu, and G. M. Erdodi, "Wind turbines optimal operation at time variable wind speeds," Applied Sciences, Vol. 10, No. 12, 4232, 2020. Google Scholar

9. Qi, L., L. Zheng, X. Bai, Q. Chen, J. Chen, and Y. Chen, "Nonlinear maximum power point tracking control method for wind turbines considering dynamics," Applied Sciences, Vol. 10, 811, 2020. Google Scholar

10. Liu, H., "Wind power system for grid-connection based on PMSG and PI controlling under variable wind speed," Journal of Physics: Conference Series, Vol. 2254, No. 1, IOP Publishing, 2022. Google Scholar

11. Imad, A., S. El Hani, A. Echchaachouai, and A. A. Energy, "Robust active disturbance rejection control of a direct driven PMSG wind turbine," 2017 International Renewable and Sustainable Energy Conference (IRSEC), 1-6, Tangier, Morocco, 2017.

12. Bin, Z., Introduction to Active Disturbance Rejection Control, Beijing University of Aeronautics and Astronautics Press, 2017.

13. Lin, P., Z. Wu, Z. Fei, and X.-M. Sun, "A generalized PID interpretation for high-order LADRC and cascade LADRC for servo systems," IEEE Transactions on Industrial Electronics, Vol. 69, No. 5, 5207-5214, May 2022. Google Scholar

14. Ayadi, M., O. Naifar, and N. Derbel, "High-order sliding mode control for variable speed PMSG-wind turbine-based disturbance observer," International Journal of Modelling, Identification and Control, Vol. 32, No. 1, 85-92, 2019. Google Scholar

15. Luo, B., S. Peng, Y. Zhang, et al. "A fault-tolerant control Strategy for D-PMSG wind power generation system," Progress In Electromagnetics Research C, Vol. 123, 75-89, 2022. Google Scholar

16. Li, S., J. Li, Y. Tang, et al. "Model-based model predictive control for a direct-driven permanent magnet synchronous generator with internal and external disturbances," Transactions of the Institute of Measurement and Control, Vol. 42, No. 3, 586-597, 2020. Google Scholar

17. Han, J., "From PID technology to ‘auto-disturbance control’ technology," Control Engineering of China, Vol. 9, No. 3, 13-18, 2002. Google Scholar

18. Gao, Z., "Scaling and bandwidth-parameterization based controller tuning," ACC, 2003. Google Scholar

19. Zhou, K., M. Ai, Y. Sun, et al. "PMSM vector control strategy based on active disturbance rejection controller," Energies, Vol. 12, No. 20, 3827, 2019. Google Scholar

20. Ma, R., X. Guo, Y. Zhang, and J. Gui, "PMSG offshore wind power system control using SMC and ADRC with fast SVPWM in complicated environment," Electrical Engineering, Vol. 105, 2751-2767, 2023. Google Scholar

21. Zhang, Lanhong, Sheng Li, and Qingjie Zhang, "Design of active disturbance rejection controller in speed loop for permanent magnet synchronous wind power generation system," Control Engineering of China, Vol. 29, No. 9, 1645-1651, 2022. Google Scholar

22. Liu, C., G. Luo, Z. Chen, et al. "Measurement delay compensated LADRC based current controller design for PMSM drives with a simple parameter tuning method," ISA transactions, Vol. 101, 482-492, 2020. Google Scholar

Dr. Bing Luo

Dr. Bozhong Liu

Dr. Sicheng Peng

Dr. Zhi Yu

Dr. Yang Zhang